Jetpack Adventures
Services Log-All Records

S.No Service Log Location Description Hours Service Type Comment Name Date Print
1 PWC
Penrith yamaha 1800 200plus
Oil Change
Replace
Oil Filter
Replace
Propellor Change
Inspect
Flyboard boots
Inspect
Pump Bolt
Inspect
Hose
Inspect
full check all items including in water test and after inspection - all 100% certified ready for flight GREG 29, Dec, 2020       
2 PWC
Central black and orange unit rxp 215 286
Oil Change
Inspect
Oil Filter
Replace
Supercharger
Inspect
Jetpumpbearing
Inspect
Propellor Change
Inspect
Jetpump Liner
Inspect
Jetpack Harness
Inspect
Flyboard bearings
Inspect
Flyboard boots
Inspect
Pump Bolt
Replace
Hose
Replace
full service check of all equipment - including full range water test and after inspection - certyified ready for flight greg and derek 29, Dec, 2020       
3 Hoses
Penrith yamaha 110
Oil Change
Replace
Oil Filter
Replace
replaced hose and oil change rechecked all bolts fittings all good SCOTTY 07, Jan, 2020       
4 PWC
Perth unit 44 272
Oil Change
Replace
Oil Filter
Replace
Supercharger
Inspect
Jetpumpbearing
Inspect
Propellor Change
Replace
Jetpack Harness
Inspect
Flyboard bearings
Inspect
Flyboard boots
Inspect
Pump Bolt
Replace
Hose
Inspect
used 2nd twin prop better fit replaced liner and standard oil tested and returned to service Allan Manning 05, Jan, 2020       
5 Board
Central board kariong 100
Flyboard bearings
Inspect
Flyboard boots
Inspect
Pump Bolt
Inspect
removed inspected and replaced parts all looks good returned to service derek 03, Jan, 2020       
6 PWC
Central green machine 2006 chromie 672
Supercharger
Inspect
full failure and jam of supercharger preventing engine turn over- supercjhrger removed - gears washers look ok bearing collapse but unit whole maintained - charger removed for service awaiting refurb unit for install - noticed carbon seal support rin dave watts 09, Mar, 2019       
7 PWC
Penrith RED NON SUPERCHARGED 240
Misc item 3
Inspect
SUSPECTED BLOWN HEAD GASKET OVERHAETING PROBLEMS- CHEMICAL WATER COOLANT TEST NOT BLOWN DETERMINED COOLANT BOTTLE AND CAP IS WORN - CAP POSITION IS TO BE DOUBLE CHECKED BEFOR USE - COOLANT BOTTLE REPLACE NEXT MAJOE SERVICE - UNIT RETURNED dave watts 08, Feb, 2019       
8 PWC
Central KARIONG SKI MARK VTEC HEAD REPLACE 642
Oil Change
Replace
Oil Filter
Replace
Misc item 3
Replace
FULL TOP END REBUILD MARK VTECH NEW REFURB REPLACEMENT HEAD TITANIUM RETAINERS SKIMMED VALVLES LIGHTWEIGHT RACING TYPE NEW HEAD GASKET NEW CLAMPS ON WATER HOSES UNIT TESTED 135 / 130 /130 COMPRESSION BADLY RUSTED POT DUE TO SITTING IDLE 9 MARK V TECH 08, Feb, 2019       
9 PWC
Perth na
Misc item 3
Inspect
general inspection by technician - low compression pot 1 not idling correctly but firing in normal use- unit still approved for operation. dave watts 11, Nov, 2018       
10 PWC
Penrith RXP RED 215 UNKOWN SHOWS 22?
Misc item 3
Inspect
CLEAN GOOD MACHINE- TAKEN FROM WINTER STOCK WITH PROBLEMS IDENTIFIED BAD STARTER MOTOR - sent to seadfoo lansvale for repair- not repaired confirmed bad starter motor - confiurmed metal in motor and bad internal condition- not exactly statewd how t SEADOO LANSVALE 09, Nov, 2018       
11 PWC
Penrith NA NA
Misc item 3
Inspect
SEADOO LANSVALE INSPECTED UNIT - head off water in engine sitting idle requires rebuild - unit out of action or to be parted out SEADOO LANSVALE 12, Nov, 2018       
12 PWC
Penrith 5897 6
Oil Change
Inspect
Oil Filter
Inspect
ddhu 09, Aug, 2018       
13 Jetpump
Gold Coast jetpump on gtr unit from show team
Jetpumpbearing
Inspect
Propellor Change
Inspect
Jetpump Liner
Inspect
twin prop unit malfunction with inspection revealing strip spline unit in main proppellor - jet pump removed from service main prop remeved - jetpump bearings replaced awaitig replacement prop ALEX SERMAK 21, Apr, 2018       
14 Supercharger
Penrith green rxp
Supercharger
Replace
REPLACEMENT OF SUPERCHARGER DAVE WATTS 20, Apr, 2018       
15 Jetpump
Penrith jetpump non supercharged rxp
Jetpumpbearing
Inspect
Propellor Change
Inspect
Jetpump Liner
Inspect
loss of power with pwc converted to steering nozzle configuration for pyro box testing - remove ski from water remove pup and inspect - rock lodged in fin area after blades and thin rope/twine also detected - rock removed liner damaged and awaiting r SCOTTY 28, Apr, 2018       
16 PWC
Perth Unit 45 GTR 201
Misc item 3
Inspect
Unit starts but revs the 3000 rpm and wont go further for a few seconds, then runs for a few minutes and then goes in to limp mod, Oil pressure came up on the display, oil level was above the max line so removed till below the max line. and ran wall for 10 Allan 18, Mar, 2018       
17 PWC
Perth Unit 45 GTR 200
Misc item 3
Replace
Unit 45 lost power (max 3000 rpm) and went into limp mode, found malted temp sensor, replaced, returned to service. Allan 17, Mar, 2018       
18 PWC
Penrith red rxp non supercharged
Pump Bolt
Replace
broken bolt on pump replaced and returned to service DEREK ETHAN 10, Mar, 2018       
19 PWC
Perth Unit 45 GTR 191
Hose
Replace
Misc item 3
Inspect
started to miss on first flight, cheeked coils, first cylinder was the result, cheeked spark plug (ok) replaced coil (was ok), The Injector plug lead was lost and one lead had been jammed back in place, replaced plug with insulated female crimps, and retur Allan 10, Mar, 2018       
20 PWC
Perth Unit 45 GTR 176
Oil Change
Replace
Oil Filter
Replace
Jetpump Liner
Hose
Replace
Carbon seal has started leaking, have installed a bilge pump. Allan 21, Jan, 2018       
21 PWC
Penrith red rxp non supercharged
Jetpump Liner
Pump Bolt
Replace
Hose
Inspect
Misc item 3
Replace
IMPELLOR REFURB 50% NEW LINER INSTALLED PUMP REFITTED UNIT RETURNED TO SERVICE FIRST USE INDICATED 100KGS @ 6000 RPM GOES TO 5 METRES DEEMED FIT FOR SERVICE LIGHTWEIGHTS TO 100 KGS GREG 11, Feb, 2018       
22 Hoses
Gold Coast hose failure
Hose
Replace
hole 3 metre from end green hose batch 1606 hose tested to full and created in full failure tear hose replaced and unit returned to service WADE BRANDON 26, Dec, 2017       
23 PWC
Central GTR KARIONG
Oil Change
Inspect
Oil Filter
Inspect
OIL LEAKING FROM BOLT ON TOP OF OIL FILTER REMOVED ADDITIONAL O RINGS INSTALLED - LEAK RE OCCURED PROBLEN UNRESOLVED CALLED DAVE WATTS TECHNICVIAN - OIL LEVELS MONITORED CLOSELY - UNIT STILL IN OPERATION DEREK 20, Dec, 2017       
24 PWC
Penrith red rxp non supercharged
Misc item 3
Replace
sensor fault corrected with replacement sensor - unit ready for return to service DAVE WATTS 15, Dec, 2017       
25 Trailer
Gold Coast DOUBLE ALEX TRAILER
Misc item 3
Replace
REPLACED DRIVER SIDE HUB AFTER FULL BEARING FAILURE IN TRANSIT- REPLACED DISC PADS TO SAME HUB - TYRES GOOD - UNIT FRAME CLEANED ZINC PRIMED CUT SPOTS AND WHOLE TRAILER 2 PAK EPOXY COATED LUXATHANE SPARE TYRE NEEDS REFURB AND BRAKES REQUIRE ADJUST S GREG 14, Dec, 2017       
26 Trailer
Gold Coast MISC
Misc item 3
Replace
REPLACED HUBS AND BEARINGS - CLEANED FRAME = EPOXY 2 PAK COATED - TYRES ARE GOOD - AXLE NEEDS MOVING FORWARD GREG 14, Dec, 2017       
27 Jetpack
Sunshine JETPACK SUNNY COAST UNIT
Misc item 3
Inspect
UNIT RETUIRNED FROM SUNNY COAST FOR GENERAL SERVICE- AND INSPECTION- FIBERGLASS REPAIRS REQUIRED AROUND BACK BONE FRAME NEW HARNESS REQUIRED - Unit returned to factory for full refurbishment GREG 04, Dec, 2017       
28 PWC
Penrith green rxp
Misc item 3
Inspect
after full days work on saturday with no problem after a carbon seal was replaced - the unit was safety checked in the morning on the following day6 revealing water in hull over supercharger - unit removed from service awaiting dave echnician to instigate SCOTTY 04, Dec, 2017       
29 PWC
Gold Coast GTR STANDARD
Pump Bolt
Replace
broke bottom lug of jetpump right side broke bolt only top left unit replaced with spare mump returned to service RHYS 23, Nov, 2017       
30 PWC
Penrith red rxp
Misc item 3
Replace
BATTERY FLAT AGAIN - FURTHER INVESDTIGATION REQUIRED - START OF DAY - BATTERY REPLACED - OLD BATRY PUT ON CHARGE AND INTO BENCH STOCK SCOTTY 18, Nov, 2017